Recent content by dreed86
-
6.9 cranking but no start
I will try the block heater in tomorrow and go pick up a compression tester.- dreed86
- Post #60
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
I made sure the harness has continuity to each plug- dreed86
- Post #54
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
Hey David, I have bypassed the gp controller and made it manual. I also rewired the harness- dreed86
- Post #53
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
I have not tried the block heater truck yet. I was hoping that it would start with out that. Will attempt the block heater tomorrow morning and let it sit for a few hours while I am at work. also I did make sure the fuel is pumping. You can smell the fuel at the exhaust pipe- dreed86
- Post #51
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
Okay so update, have installed eight new glow plugs. Had good well charged batteries and hit the glow plug switch everything looked good unfortunately no start. Put the pedal to the floor while attempting to start. Possible it's too cold currently 34°. It did seem like it wanted to turn over a...- dreed86
- Post #49
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
I've pulled out 4 of 8 and four of them so far are bad. I'm going to have to wait till tomorrow to get the next 4 out. That one plug spot filled up with water. So I had to blow it out and shoot some more wd-40 at it- dreed86
- Post #43
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
I ordered new plugs over the weekend. Parts store said the motorcraft ones would be here today. Just need to go pick them up- dreed86
- Post #40
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
So I wanted to come on here and give a quick update on what @IDIBRONCO and I tested and found out tonight. @IDIBRONCO first started at the lift pump to verify pressure. This was good. Then checked at the Schrader valve. Again good. Then to injection pump. Finally he cracked 7 of the 8 fuel lines...- dreed86
- Post #30
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
@rhkcommander I was wondering about the Injection pump. Is it possible to have some fuel coming out of the injection pump and not be bad? If so does that mean its clogged and needs cleaning or if its a little bit. If as you say your supposed to get 1500psi and be gushing out. When I originally...- dreed86
- Post #27
- Forum: 6.9L IH & 7.3L IDI Diesels
-
-
-
6.9 cranking but no start
@rhkcommander, This information is awesome thanks a bunch. I will get started with checking this out. Side question for you. would timing by chance cause the same issue?- dreed86
- Post #19
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
@rhkcommander, I have removed that wire before and run a line from the battery to the FSS. I hear a audible click from it. Also have tried the schrader valve on the filter while cranking and fuel comes out at a good pace. Im wondering since im not getting any exhaust smoke from the pipe either...- dreed86
- Post #17
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
So even though I am getting fuel to the top of the injectors nothing is getting into the cylinders? Like I mentioned previously I did crack the hard lines on top of the injectors and get fuel coming out of the top. Does this mean I need to replace the injectors? Again sorry for this I'm...- dreed86
- Post #15
- Forum: 6.9L IH & 7.3L IDI Diesels
-
6.9 cranking but no start
This afternoon I tried to crank the engine over as i did before foot to the floor. Again no start. I did check to see if there was smoke of any color coming from the exhaust tip. Not producing smoke. Im thinking I might try replacing all the glow plugs this time. Since I have never removed them...- dreed86
- Post #12
- Forum: 6.9L IH & 7.3L IDI Diesels
