Recent content by VanDiesel

  1. VanDiesel

    NAPA Echlin Ignition vs Motorcraft Glow plug relay comparison - with pics

    For the past 25 years, I've been drilling out the rivets on the solenoids, desoldering the coil wires and disassembling used units. The copper contacts are usually blackened causing poor contact. I buff the copper contact and disc surfaces, use silicone dielectric grease, resolder and...
  2. VanDiesel

    I want to finally get Gear Vendors unit, have questions though.

    85 E250 Club Wagon with 93 7.3, C6 with GV and 3.55 gears, somewhere around 20 mpg at 60
  3. VanDiesel

    Found Banks 1st Gen COMPLETE Install Packet + Paraphernalia

    "Those C6 trucks were real dogs. Especially with 3.55 gears. They weren't great, but at least it was an automatic option." 93 7.3L IDI in 1985 E250 Club Wagon, 3.55 driven by C6 with Hayes RV torque converter through GearVendors has reached over 100 on the flat, according to GPS trip record.
  4. VanDiesel

    6.9/7.3 Fuel Line Sensors - How?

    Yep. Fortunately had in stock when changing to a pump and lines in place that needed it to preserve length.
  5. VanDiesel

    6.9/7.3 Fuel Line Sensors - How?

    Interesting. How do they work?
  6. VanDiesel

    6.9/7.3 Fuel Line Sensors - How?

    These attach to injector #1 on F series IDI and E series #4. Anyone know how they work and with what equipment?
  7. VanDiesel

    Electronic fuel pump 7.3 IDI

    The large spin on filter also acts as a fuel reservoir, and as a heater for the fuel. On top of the engine, this is efficient, more so on the vans. If you run vegetable oil from the back tank, this location heats the oil to a viscosity level adequate to run the engine.
  8. VanDiesel

    Electronic fuel pump 7.3 IDI

    I cut an access hatch above the sender hole in the tank in the floor of our 1985 E250, that is removable with sheet metal screws. It's not necessary to drop the tank or empty it to gain access to the pickup and filter. A 1984 diesel van does not have a stock in tank pump and the hole is small. I...
  9. VanDiesel

    Electronic fuel pump 7.3 IDI

    There should be a filter on the pickup in the tank, a water separator, your mechanical then electric lift pump (if you use both), the inline heater in tube or housing, then the large spin-on filter just before the injection pump.
  10. VanDiesel

    Why did my 7.3 not like ether today.

    If you think you have to use ether, your system is not in proper repair as designed. If you break off a glow plug tip, you'll be lucky not to damage the piston, bore, or valves, as it rattles around. At the least, you'll have to pull the head to find out if you need another engine.
  11. VanDiesel

    Electronic fuel pump 7.3 IDI

    The electric pump should be AFTER the mechanical if you use both. Otherwise, should the mechanical pump diaphragm rupture, the electric pump will start filling your engine crankcase with fuel. We ran IDI engines like this for years. We eventually just used electric pumps and blocked off the...
  12. VanDiesel

    Is there a difference in c6 transmissions from pickups and motorhomes?

    The output shaft has come out of the back of the C6 in your pictures. You could swap the regular long tailshaft housing, after disassembling and checking the motorhome extension parts. I'd like to see what that prtion looks like This is not a 4x4 transmission. I have owned and rebuilt multiple...
  13. VanDiesel

    1983 6.9 engine oil cooler bypass kit?

    From the looks of it if everything else fits, only the exhaust, cooler and motor mount from the van style need changing. Any of the fuel filter styles will work.
  14. VanDiesel

    1983 6.9 engine oil cooler bypass kit?

    This looks just like the 83-91 driver side of E250/350 van application: exhaust, cooler, motor mount upper.
  15. VanDiesel

    1983 6.9 engine oil cooler bypass kit?

    Here's a 93 7.3 IDI from a pickup, being prepared to install into an 83-91 van. The manifold, cooler and mount all had to be swapped for the van versions. BTW, the swap was done by one person in a home garage with no help...
See more

Latest posts

Forum statistics

Threads
91,306
Posts
1,130,044
Members
24,117
Latest member
olsen726

Members online

Total: 611 (members: 4, guests: 607)

Share this page

Top