Search results

  1. C

    OD light flashing hard 1-2 shifts

    Update: you guys are the best...FordF250 you were right, I found the white and yellow wire was sitting on top of the front driveline wore bare. After splicing the wire all the issues went away. Thanks for everyone's help. I'm on the road and she's running great!
  2. C

    OD light flashing hard 1-2 shifts

    I have installed the correct pack and a new harness... Fits much better. Before I installed I checked ohms for solenoids and everything checked out in spec (20+ and 5+ for epc). Upon start up it runs much better. Shifts through all gears but I'm still getting a code 99 flashing and a hard...
  3. C

    OD light flashing hard 1-2 shifts

    I was able to get the plastic sleeve off that fordF250 mentioned and the plug fits into the solenoid pack. After a test drive things seems to better, but not completely... From a stop the truck acts like you are driving a manual and riding the clutch to take off in third. High RPM's to go...
  4. C

    OD light flashing hard 1-2 shifts

    Update: Thanks for the help everyone, turns out the solenoid pack was bad and I got into it this past weekend. The removal and installation went smooth until I went to plug the harness into the solenoid pack. It would not fit, closer inspection found a "ring" around the plug that would not...
  5. C

    OD light flashing hard 1-2 shifts

    Thanks for the help, so the recommendation is to adjust the tps to 1.2 and then purchase the wire harness to check the solenoid pack. Could you walk through using the new harness to troubleshoot the solenoid pack issue? I read the hyperlink but not sure how to use the harness in the test...
  6. C

    OD light flashing hard 1-2 shifts

    I received my scanner today and got codes 23 and 99. I replaced the tps with the gray one, 1.3 and 4v. Took out sensor on passenger side of tranny behind Heat guard and applied dielectric grease, also greased sensor on top of rear diff . Cleared codes but they both came back, any other...
  7. C

    OD light flashing hard 1-2 shifts

    Yes they are
  8. C

    OD light flashing hard 1-2 shifts

    I'll pick one up and post the codes, thanks!
  9. C

    OD light flashing hard 1-2 shifts

    OD light flashing - hard shifts OD light started to flash, but no engine light was flashing. Found the TPS to be old style so I replaced it. Voltages are good, 1.3 and 4, but light still flashes. Removed battery cables to clear codes, did not work. Trucks shifts well except that it shifts...
  10. C

    Shake at low RPM's after replacing fuel return lines

    sorry, yes lb-ft. Ill try the bad injector and post the results. Thanks for all the help
  11. C

    Shake at low RPM's after replacing fuel return lines

    That may have been where I went wrong with not cleaning the bore holes. debris may have entered the hole which could cause the miss?
  12. C

    Shake at low RPM's after replacing fuel return lines

    Thanks for the help, sorry for the inexperience but it was the tip that was loose, the very bottom of the injector. So when do you need to replace the copper washers? When the o-rings, caps, and lines don't fix the fuel leak? And, yes I replaced all copper washers, and got the old ones...
  13. C

    Shake at low RPM's after replacing fuel return lines

    yeah, I already tried that. I cracked each one loose and each one made the engine run worse, and the RPM's remained constant. As I was doing the return line replacement I did notice that one of the heads of an injector had come loose so I hand tightened it? All the injectors showed minimal...
  14. C

    Shake at low RPM's after replacing fuel return lines

    yep, no leaks now. I felt all the caps seat, tightened all injector nuts. I haven't checked the nuts on the back of the IP though...
  15. C

    Shake at low RPM's after replacing fuel return lines

    The truck was running great, I noticed a fuel leak coming from the injectors. Replaced all the lines per SOP on this forum. Before I put steel lines back on I turned engine over and made sure fuel was coming out of each line. Put it back together and it feels like it is missing. You can feel...
  16. C

    7.3 w/Turbo Mild Upgrade - Recommendations

    I havent messed with the pump at all. Ill look into its adjustment and look forward to the moose jr next year! Do i need a pyrometer before i adjust the fuel?
  17. C

    7.3 w/Turbo Mild Upgrade - Recommendations

    That sounds perfect for my setup! Would typ4's BB injectors still be the injector of choice for the moose jr?
  18. C

    7.3 w/Turbo Mild Upgrade - Recommendations

    thanks guys for the replies, what risks would i be taking if I installed the moose pump without an intercooler? I don't race it, or do any regular heavy pulling...
  19. C

    7.3 w/Turbo Mild Upgrade - Recommendations

    7.3 w/Turbo Mild Upgrade - Any Recommendations? Hey guys, have a 1990 7.3 with ATS turbo, pickup has 94k original miles and runs great besides the puff of white smoke when it starts cold here in Wyoming . Been doing a lot of research around here to prepare for a fuel system overhaul in the...
  20. C

    $2,000 for a transmission rebuild?

    Thanks for everybody's help on this issue, sounds like everyone has there opinions and what works best for them. That's why this site is so great, you get everyone's opinions and then you can make your decision. Here is the outcome of my issue. Having a young family makes it tough to drop 2...
  21. C

    $2,000 for a transmission rebuild?

    you are right midnightblade that guy had the same problem. I took the dust plate off and it looks like the original TC, dropped the pan and the fluid looks pretty, doesn't smell bad and the magnet doesnt look like a chia pet! I'll let you know if changing the TC fixes it. Any suggestions for...
  22. C

    $2,000 for a transmission rebuild?

    fordf250hdxlt - you're right, good advice I'll start there.
  23. C

    $2,000 for a transmission rebuild?

    What are your thoughts about buying a rebuilt tranny and doing the removal and install yourself?
  24. C

    $2,000 for a transmission rebuild?

    nevermind, I see it in your truck's specs
  25. C

    $2,000 for a transmission rebuild?

    Goofyexponent, did you rebuild your tranny? Or replace it with the ZF?

Latest posts

Forum statistics

Threads
91,327
Posts
1,130,420
Members
24,133
Latest member
Nanohawk

Members online

Total: 545 (members: 4, guests: 541)

Share this page

Top