Recent content by crabbypaul

  1. C

    -40 winters and starting

    I have seen those temps in Minnesota and always run 15-40 oil. The trick to dependable starts is good batteries and glow plugs. The engine should start instantly now at 40 degrees with the glow plugs if not figure out why when it is warm enough to work on. I would be careful with a winter front...
  2. C

    ZF5 internal damage/ do I need to replace?

    Justin sorry it took me so long to reply I don't look at this web site very often. When that happened to my transmission the pressure plate and flywheel had failed I don't know if one caused the other or which one failed first but at that time a LUK flywheel and clutch kit were installed. When...
  3. C

    ZF5 internal damage/ do I need to replace?

    I just looked at the pictures again the piece in the top and bottom picture is the input shaft I would take a long look at the flywheel and clutch assembly I think out of balance condition with my clutch assembly caused a very similar failure with my pickup.
  4. C

    ZF5 internal damage/ do I need to replace?

    When I rebuilt the transmission in my truck I bought the parts from Midwest transmission they will give you tech support on the phone and will advise you on parts replacement. If that was my transmission I would be replacing all the bearings and that gear it appears that the inside race were the...
  5. C

    ZF5 diesel front case section

    I was planning in using this to convert a 460 transmission but ended not using it. $100 plus shipping
  6. C

    Bricknose wiper parking problem

    To check the Park switch in the wiper motor unplug it and jump the low speed side to power with fused jumper wire. This is the terminal that the White wire plugs into. While the wipers are running take a 12 volt test light that is hooked to 12 volts and touch the terminal that would plug into...
  7. C

    Need advice on Dana 60

    I just installed a Dana 60 front axle out of 97 F350 in the 86 F250 , this has a ZF5 speed that replaced a T19 4 speed this was done a few years ago. The front drive shaft that was in it is about 1.5 inches to long. The drive shaft that was in the 97 F350 is way to long , I grabbed that when I...
  8. C

    2 to 4wd swap ideas

    If you are going to snow plow to make money you will have to have an automatic for that the C6 is almost indestructible.
  9. C

    OTC injector tester

    This is sold
  10. C

    6.9 idi with zf5 trans

    I used LuK LFW127 Flywheel and LuK 07-131 Clutch Set that were purchased from Amazon. Both are still working good
  11. C

    My facet mechanical to electric fuel pump conversion review.

    I have been running a Holley 12-801-1 electric fuel pump for over 10 years it has been on 2 different trucks it is power from a relay and draws about 2 amp. Its looking pretty rough in the photo.
  12. C

    OTC injector tester

    I will get it ready to ship find a box and get some packing material. Just let me know when your ready.
  13. C

    OTC injector tester

    Yes
  14. C

    OTC injector tester

    Make an offer this is used to test and adjust injector opening pressure. I would like to sell it to someone that will use it.
  15. C

    OTC injector tester

    OTC nozl-rater diesel injector tester $150 plus shipping
See more

Latest posts

Forum statistics

Threads
91,280
Posts
1,129,764
Members
24,098
Latest member
William88

Members online

Total: 630 (members: 2, guests: 628)

Share this page

Top